The car has a rigid rear axle in the form of a beam, consisting of a main gear housing and axle housings pressed into it

A feature of the ZMZ-40524 engine ignition system is the presence of four separate ignition coils installed directly on the spark plugs, instead of two separately installed coils serving two engine cylinders each

Checking electrical circuits

To measure electrical parameters, a digital or analog (arrow) tester is used - a voltmeter, ohmmeter and other devices combined in one housing

Removal and installation of the crankshaft of the ZMZ-406 engine

Remove the oil sump and crankcase gasket

The engine is removed from the car upwards, having previously removed the gearbox

To remove the engine, a lifting device with a lifting capacity of at least 300 kg is required

Cause of malfunction - Remedy

The power system consists of a fuel tank, fuel lines, a fuel pump, a sump filter, a fine fuel filter, a carburetor with throttle and air damper drives, and an air filter

Fuel tank of a Gazelle car

If the seal of the fuel tank is damaged, it should be removed from the vehicle

Removing the steering mechanism

To do this you need to do the following:

The causes of malfunction of the master brake cylinder are wear or loss of elasticity of the cuffs, wear of the working surfaces of the cylinder and pistons, swelling of the cuffs from mineral oils entering the system, clogging of the compensation holes

Disassembling the gearbox synchronizer

Check for the presence of aligned marks on the hub and sliding clutch of the synchronizer and, if not, mark them.

The technical condition of the engine is constantly changing during operation

Engine ZMZ-4061 and 4063 carburetor, four-cylinder, in-line, four-stroke with four valves per cylinder and two camshafts in the cylinder head

Ignition coils are designed to generate high voltage electric current to ignite the working mixture in the engine cylinders

Monoblock - a single one-piece design of the cylinder block and cylinder head without a gas joint

This solution allows you to work with high combustion pressure in the engine cylinders and ensure its high energy performance

The microprocessor ignition system is designed to ignite the working mixture in the engine cylinders by setting the optimal ignition timing for a given engine operation mode

It is not recommended to unscrew the screws securing the throttle valves on the axles and remove the valves unless absolutely necessary, since their displacement can lead to jamming of the valves in the channels

On a Gazelle car, steering can be installed both without power steering and with power steering